8GENERATOR SAFETYRefuel With CareGasoline is extremely flammable, and gasoline vapor can explode.Allow the engine to cool if the generator has been in
9GENERATOR SAFETYSAFETY LABEL LOCATIONSThese labels warn you of potential hazards that can cause seriousinjury. Read them carefully. If a label comes
10CONTROLS & FEATURESCOMPONENT & CONTROL LOCATIONSENGINE SWITCHOUTPUTINDICATORi-MONITORBUTTONi-MONITORFUEL VALVEVOLTAGE SELECTOR SWITCHCIRCUIT
11CONTROL & FEATURESHANDLEAIR CLEANERFUEL TANK CAPSTARTER GRIPGROUND TERMINALSTANDOIL DRAIN PLUGOIL FILLERCAP/DIPSTICKWHEELMUFFLER TIPSPARK PLUGIN
−−−−12CONTROL & FEATURESCONTROLSFuel Valve LeverEngine SwitchFUEL VALVE LEVEROOFFFFOONNOOFFFFOONNOOFFFFSSTTAARRTTENGINE SWITCHENGINE SWITCHRREEMMO
−−13CONTROL & FEATURESRecoil StarterEcoThrottle SwitchSTARTER GRIPONOFFECOTHROTTLE SWITCHPulling the starter grip operatesthe recoil starter to cr
14CONTROL & FEATURESVoltage Selector SwitchSwitch PositionAC Circuit Protectors120/240V:120V ONLY:AC CIRCUIT PROTECTORPUSHONVOLTAGE SELECTOR SWITC
15CONTROL & FEATURESFolding HandleTo Extend HandleTo Fold HandleHANDLEHANDLE LOCK LEVERHandletransportpositionGeneratorstationarypositionThe folda
16CONTROL & FEATURESFEATURESGround TerminalGROUND TERMINALThe ground terminal is connected to the frame of the generator, themetal non-current-car
17CONTROL & FEATURESOutput IndicatorOverload IndicatorOUTPUTINDICATOR(GREEN)OVERLOADINDICATOR (RED)The output indicator (green) is illuminated whe
Keep this owner’s manual handy, so you can refer to it at any time.This owner’s manual is considered a permanent part of the generatorand should remai
18CONTROL & FEATURESOil Alert IndicatorIt blinks.OIL ALERT(RED)The Oil Alert system is designed to prevent engine damage causedby an insufficient
−19CONTROL & FEATURESi-Monitori-Monitor at Start Upi-Monitor Display Mode 1 Total Operating Hoursi-Monitor DisplayDisplay Backlight Flashesi-MONIT
−−−20CONTROL & FEATURESi-Monitor Display Mode 2 Power Outputi-Monitor Display Mode 3 Engine RPMi-Monitor Display Mode 4 Battery VoltageTMTMTMTMThi
21CONTROL & FEATURESi-Monitor Low Battery Messagei-Monitor System Error MessagesOVERLOAD INDICATOR LIGHTERROR MESSAGE(Example: E-01)TMTMTMTMIf the
22CONTROL & FEATURESFuel GaugeFUEL TANK CAPFULLEMPTYFUEL GAUGEThe fuel gauge is a mechanical device that measures the fuel level inthe tank. The r
23BEFORE OPERATIONARE YOU READY TO GET STARTED?KnowledgeIS YOUR GENERATOR READY TO GO?Your safety is your responsibility. A little time spent in prepa
24BEFORE OPERATIONCheck the EngineMaintenance CoverMAINTENANCE COVERCheck the oil level (see page ). A low oil level will cause the OilAlertsystem to
25SAFE OPERATING PRECAUTIONSOPERATIONBefore operating the generator for the first time, please review theGENERATOR SAFETYsection and the chapter title
26OPERATIONSTARTING THE ENGINEFUEL VALVE LEVEROONNOOFFFFVOLTAGE SELECTOR SWITCH120VONLY120V/240VECOTHROTTLE SWITCHONOOFFFFTMRefer to Safe Operating Pr
27OPERATIONOONNOOFFFFSSTTAARRTTENGINE SWITCHStart the engineUsing the electric starter:Using the electric starter for more than 5 seconds at a time wi
1INTRODUCTIONCongratulations on your selection of a Honda generator. We arecertain you will be pleased with your purchase of one of the finestgenerato
28OPERATIONOONNENGINE SWITCHONOOFFFFOOFFFFSTARTER GRIPECOTHROTTLE SWITCHUsing the recoil starter:Turn the engine switch tothe ON position.Pull the sta
29OPERATIONStarting the engine with remote control (optional part)ONOOFFFFOFFENGINE SWITCHREMOTEPILOT LAMPFUEL VALVESTART BUTTONDetermine the voltage
30OPERATIONSTOPPING THE ENGINEOONNENGINE SWITCHOONNFUEL VALVE LEVEROOFFFFOOFFFFTo stop the engine in an emergency, simply turn the engine switch tothe
31OPERATIONStopping the engine with remote control (optional part)ONOOFFFFFUEL VALVEENGINE SWITCHREMOTESTOP BUTTONPILOT LAMPOOFFFFTurn the engine swit
−32OPERATIONAC OPERATION120V/240V120V ONLYVOLTAGE SELECTOR SWITCHOUTPUTINDICATOR(GREEN)OVERLOADINDICATOR(RED)If an appliance begins to operate abnorma
33OPERATIONPLUGMost motorized appliancesrequire more than their ratedwattage for startup.Plug in the appliance.Determine if the cause is a short circu
34OPERATIONAC ApplicationsBefore connecting an appliance or power cord to the generator:Make sure that it is in good working order. Faulty appliances
++++++35OPERATIONAC Receptacle SelectionThe generator has separate main power producing circuits. These twocircuits supply power to different receptac
36OPERATION120V 20A120/240V 30A120/240V 30A120V 30A 120V 20AExample: EM5000isReceptacle 1 has a 15A load connected to it. Receptacle 3 has a 10Aload c
37OPERATIONECOTHROTTLE SYSTEMECOTHROTTLE SWITCHOOFFFFONTMTMTMTMTMTMTMAppliances with large start-up power demands may not allow theengine to reach nor
−−−−−−2A FEW WORDS ABOUT SAFETYSafety LabelsSafety MessagesSafety HeadingsSafety SectionInstructionsYour safety and the safety of others are very impo
38OPERATIONSTAND BY POWERSystem GroundConnections to a Building’s Electrical SystemHonda portable generators have a system ground that connects thegen
39OPERATIONSpecial RequirementsThere may be Federal or State Occupational Safety and HealthAdministration (OSHA) regulations, local codes, or ordinanc
40SERVICING YOUR GENERATORTHE IMPORTANCE OF MAINTENANCEMaintenance, replacement, or repair of the emission control devicesand systems may be performed
−−−41SERVICING YOUR GENERATORMAINTENANCE SAFETYSafety PrecautionsCarbon monoxide poisoning from engine exhaust.Burns from hot parts.Injury from moving
42SERVICING YOUR GENERATORMAINTENANCE SCHEDULEREGULAR SERVICE PERIOD (3)ITEM EachusePerform at every indicated month oroperating hour interval, whiche
43SERVICING YOUR GENERATORREFUELINGFULLEMPTYFUEL TANK CAPFUEL GAUGEMAXIMUM FUEL LEVEL(FUEL STRAINER SHOULDER)Gasoline is highly flammable andexplosive
44SERVICING YOUR GENERATORFUEL RECOMMENDATIONSUse unleaded gasoline with a pump octane rating of 86 or higher.This engine is certified to operate on u
45SERVICING YOUR GENERATORENGINE OIL LEVEL CHECKUPPER LIMITOIL FILLER CAPDIPSTICKCheck the engine oil level with the generator on a level surface and
46SERVICING YOUR GENERATORENGINE OIL CHANGEUPPER LIMITOIL DRAIN PLUGOIL FILLER CAP/DIPSTICKSEALINGWASHEROIL FILLER CAP/DIPSTICKDrain the oil while the
−47SERVICING YOUR GENERATORENGINE OIL RECOMMENDATIONSSAE Viscosity GradesAMBIENT TEMPERATUREOil is a major factor affecting performance and service li
3CONTENTS...GENERATOR SAFETY .6...
48SERVICING YOUR GENERATORAIR CLEANER SERVICEAIR CLEANERCOVERCOVER SCREWFOAM AIR FILTERRemove the foam air filter from the air cleaner cover.Loosen th
49SERVICING YOUR GENERATORFOAM AIR FILTER CLEANINGFOAM AIR FILTERA dirty foam air filter will restrict air flow to the carburetor, reducingengine perf
50SERVICING YOUR GENERATORSEDIMENT CUP CLEANINGSEDIMENT CUPO-RINGFUEL VALVE LEVERONOFFKEYReinstall the O-ring and sediment cup.Wash the sediment cup a
51SERVICING YOUR GENERATORRecommended spark plugs:SPARK PLUG SERVICESPARK PLUGINSPECTION COVERCOVER SCREWSPARK PLUG WRENCHIncorrect spark plugs can ca
−−−−−52SERVICING YOUR GENERATORSEALING WASHER0.028 0.031 in(0.70 0.80 mm)Inspect the spark plug. Replaceit if the electrodes are worn or ifthe insulat
53SERVICING YOUR GENERATORSPARK ARRESTER SERVICEMUFFLER PROTECTOR8 mm FLANGE BOLT (2)REAR BAR6 mm FLANGE NUT (6)The spark arrester must be serviced ev
54SERVICING YOUR GENERATOREXHAUST TAIL PIPESPARK ARRESTER6 mm FLANGE BOLT6 mm FLANGE BOLTSTORQUE:TORQUE:Remove the three 6 mm flange bolts, and remove
−−−55SERVICING YOUR GENERATORBATTERY SERVICEEmergency ProceduresEyesSkinSwallowingYour generator’s engine charging system charges the battery whilethe
−−+++−56SERVICING YOUR GENERATORBattery RemovalWARNING:Wash hands after handling.POSITIVE ( ) CABLENEGATIVE ( ) CABLEMAINTENANCE COVERCOVER SCREWBATTE
−−+++−57SERVICING YOUR GENERATORBattery ChargingBattery InstallationThe battery gives off explosivehydrogen gas during normaloperation.A spark or flam
4CONTENTS...OPERATION .25...
58SERVICING YOUR GENERATORFUSESpecified fuse:FUSE HOLDERFUSE (15A)FUSE HOLDER COVERFUSE (1A)MAINTENANCECOVERCOVERSCREWIn the event of fuse failure, lo
59STORAGE PREPARATIONCleaningFuelSTORAGEProper storage preparation is essential for keeping your generatortrouble-free and looking good. The following
60STORAGEAdding a Gasoline Stabilizer to Extend Fuel Storage LifeWhen adding a gasoline stabilizer, fill the fuel tank with fresh gasoline.If only par
61STORAGEDraining the Fuel Tank and CarburetorDRAIN SCREWGasoline is highly flammable andexplosive.You can be burned or seriouslyinjured when handling
−62STORAGEEngine OilChange the engine oil (see page ).Pour a tablespoon (5 10 cc) of clean engine oil into the cylinder.Remove the spark plug (see pag
63STORAGESTORAGE PRECAUTIONSREMOVAL FROM STORAGEIf your generator will be stored with gasoline in the fuel tank andcarburetor, it is important to redu
64TRANSPORTINGIf the generator has been running, allow the engine to cool for at least15 minutes before loading the generator on the transport vehicle
65ENGINE PROBLEMSEngine Will NotStartPossible Cause CorrectionTAKING CARE OF UNEXPECTED PROBLEMSFuel valve leverOFF.Engine switch OFF.Out of fuel.Bad
66TAKING CARE OF UNEXPECTED PROBLEMSEngine LacksPowerPossible cause CorrectionCheck air filter.Check fuel.Take generator toan authorizedHonda servicin
67TAKING CARE OF UNEXPECTED PROBLEMSGENERATOR PROBLEMSNo Power at theAC ReceptaclesPossible Cause CorrectionCheck AC load.Stop and restartthe engine.C
5CONTENTS...TRANSPORTING .64...
68TECHNICAL INFORMATIONTECHNICAL & CONSUMER INFORMATIONFRAME SERIAL NUMBERSerial Number LocationRecord the frame serial number in the space below.
69TECHNICAL & CONSUMER INFORMATIONCarburetor Modification for High Altitude OperationAt high altitude, the standard carburetor air-fuel mixture wi
70TECHNICAL & CONSUMER INFORMATIONOxygenated FuelsMETHANOLETHANOLMTBESome conventional gasolines are being blended with alcohol or anether compoun
71TECHNICAL & CONSUMER INFORMATIONEmission Control System InformationSource of EmissionsThe U.S. and California Clean Air ActsTampering and Alteri
72TECHNICAL & CONSUMER INFORMATIONProblems That May Affect EmissionsReplacement PartsMaintenanceIf you are aware of any of the following symptoms,
−−−73TECHNICAL & CONSUMER INFORMATIONAir IndexAn Air Index Information hang tag/label is applied to engines certifiedto an emission durability tim
××±±−〈 〉−−**74TECHNICAL & CONSUMER INFORMATIONSpecificationsEM5000isSPECIFICATIONDimensionsEngineGeneratorTuneup SpecificationsITEM MAINTENANCEEAJ
±××±−〈 〉−−**75TECHNICAL & CONSUMER INFORMATIONTuneup SpecificationsITEM SPECIFICATION MAINTENANCEDimensionsEngineGeneratorEM7000isEAHJEM7000isSpar
76TECHNICAL & CONSUMER INFORMATIONWiring Diagram06/03/18 13:05:18 31Z11600_077
77TECHNICAL & CONSUMER INFORMATIONCONSUMER INFORMATIONHonda PublicationsShop ManualParts CatalogThese publications will give you additional inform
6GENERATOR SAFETYOperator ResponsibilityCarbon Monoxide HazardsIMPORTANT SAFETY INFORMATIONHonda generators are designed for use with electrical equip
78TECHNICAL & CONSUMER INFORMATIONCustomer Service InformationHonda Power Equipment dealership personnel are trainedprofessionals. They should be
79ASSEMBLYSAFETYThe Importance of Proper AssemblyImproper assembly can cause anunsafe condition that can lead toserious injury or death.Follow the pro
□□□□80ASSEMBLYImportant Safety PrecautionsCarbon monoxide poisoning from engine exhaust.Injury from moving parts.Burns from hot parts.Make sure you ha
×××81ASSEMBLYASSEMBLYUnpackingLoose PartsTools Required:Compare the loose parts with the inventory list below.Remove the generator and loose parts box
−− −×××××82ASSEMBLYWheel Kit InstallationTORQUE:AXLEWHEEL (2)STAND (2)LONGER20 mm WASHER (2)8 16 mm FLANGE BOLT (4)4.0 28 mm COTTER PIN (2)816mmFLANGE
−− −83ASSEMBLYHandle InstallationTo Extend Handle:TORQUE:SPRING WASHER (2)12 mm WASHER (2)HANDLE HOLDER BOLT (2)HANDLE ASSEMBLYHANDLEHANDLE LOCK LEVER
−− −××84ASSEMBLYRear Bar InstallationTORQUE:8 45mm FLANGE BOLT (2)REAR BAR17 22 lbf·ft (24 29 N·m , 2.4 3.0 kgf·m)Install the rear bar on the generato
++−+−85ASSEMBLYBatteryWARNING:Wash hands after handling.TWIST CLIPBATTERY STRAPRED CABLE(POSITIVE ( ) CABLE)BLACK CABLE(NEGATIVE ( ) CABLE)To secure t
++−○○+−+−86ASSEMBLYWARNING:Wash hands after handling.BATTERY STRAPTWIST CLIPRED CABLE(POSITIVE ( ) CABLE)BLACK CABLE(NEGATIVE ( ) CABLE)BATTERYPart Nu
87ASSEMBLYEngine OilWITHOUT OILFuelSAE Viscosity GradesAMBIENT TEMPERATUREOIL FILLER HOLEUPPER LIMITFILLER CAP/DIPSTICKThe generator is shippedin the
−−−7GENERATOR SAFETYElectric Shock HazardsFire and Burn HazardsThe generator produces enough electric power to cause a seriousshock or electrocution i
88ASSEMBLYBEFORE OPERATIONSTARTING THE ENGINESTOPPING THE ENGINEGENERATOR SAFETYCONTROLS & FEATURESOPERATIONBefore using your generator, you shoul
89OPTIONAL PARTSRemote Control KitKNOCKOUTMAINTENANCE COVER(backside)PLUGRemove the maintenance cover (see page ).Remove the plug from the 6-pin conne
90OPTIONAL PARTSCABLE TIEREMOTECONTROL CABLEREMOTE CONTROL CABLEREMOTE CONTROL BOXMAINTENANCE COVERGROMMETPLUGPass the remote control cable through th
−− −×91OPTIONAL PARTSHanger KitTORQUE:HANGERGENERATORSIDEHANGER BRACKET (2)8 16 mm FLANGE BOLT (4)HANGERFUEL TANKRIBPosition the hanger at the generat
92INDEXABCE...AC Applications . 34...
93INDEXFGHIKL...Knowledge . 23...
94INDEXMOQR...QUICK REFERENCE INFORMATION . Inside back cover...
95INDEXSTUVW...SAFE OPERATING PRECAUTIONS . 25...
96MEMO05/04/25 09:50:27 31Z11600_097
−−QUICK REFERENCE INFORMATIONUnleaded gasoline with a pumpoctane rating of 86 or higher0.028 0.031 in (0.70 0.80 mm)TypeTypePart NumberSubsequentBPR5E
Comments to this Manuals